Budding Enthusiast. 93. Name: Shaun. Ford Model: Focus Mk2 1.6tdci. Ford Year: 2006. UK/Ireland Location: Cambridgeshire. Posted February 10, 2016. The 1.6 tdci focus engines seem to draw a lot of oil from the rocker cover breather into the air intake , I've seen a topic on here about fitting an oil catch tank but I was thinking , can I just 3) Disconnect the TPS (Throttle Body Position Sensor) (small red locking clip pops up then whole plug just pulls of sensor) 4) Remove the 4 Torx screw on the TB and gently lift throttle body of. Under you will see the rubber gaskets which can be removed and cleaned or replaced depending on condition. Steps to Reinstall. 4 Unscrew the fuel filter bracket fixing bolts. Use a drive socket #10. Use a ratchet wrench. 5 Remove the fuel filter fastening bracket. 6 Unscrew the fuel filter bracket. Use a drive socket #Е11. Car repair and service. Ford Focus 1.6 TDCI Oil and Filter ChangeModel years: 2011, 2012, 2013, 2014 and 2015.21mm Sump Plug Torque 35Nm.Oil filter housing 27mm Torque to 25Nm. 9 Move the container under the oil filter. 10 Unscrew the oil filter. 11 Prepare a container for the old oil filter. Put the old oil filter in the container. CLUB.AUTODOC.CO.UK 5–11 Caution! The oil may be hot. Wait until the oil has completely drained from the drainage hole. Replacement: engine oil and filter – FORD Kuga Mk2 (DM2). Tip: Just join the owners club, can some one please tell me where is the gearbox drain and filler plugs for my mk2 hatchback 1.6 16v petrol engine focus, 2009 year, it has 70,000 on the clock and I want to do a oil + filter + gearbox oil change, I don't know when all the oil was last change, I just bought this car and. what this issue sorted. many JW1982. The Focus MK2 Petrol version does not have a changeable fuel filter. There is only a strainer which is mounted on the intake of the fuel pump in the fuel tank. As far as I know the strainer is not available as a spare part. If you want to change the strainer you have to replace the complete fuel sender unit. 44. Name: Peter. Ford Model: Focus 2.5 sport 1.6 TDCI. Ford Year: 2011. UK/Ireland Location: West Midlands. Posted November 7, 2016. I have a service oil warning light coming on whenever I start the car. I have tried the clutch and brake pedal solution for removing it but to no avail. XGH02.